Product ID:N5291 HIGH GLOSS BLUE ENAMEL
MSDS Date:12/20/1995
FSC:8010
NIIN:00-853-1859
MSDS Number: BZSWG

NILES CHEMICAL PAINT CO

3RD AND FORT ST
NILES, MI 49120
US

Emergency Phone: 616-683-3370 OR 219-236-5856

Info Phone: 616-683-3370 OR 219-236-5856

Preparer: MIKE LICHATOWICH

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

ALKYD RESIN SOLUTION

CAS: 68459-31-4

Fraction By Weight: 52.0%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM/STEL 200 PPM

BUTYL ACETATE (VAPOR PRESSURE 10 MM HG @ 20C)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 30.0%

OSHA PEL 100 PPM

ACGIH TLV: 150 PPM/STEL 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BARIUM SULFATE (SARA 313)

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: 5.0%

OSHA PEL 5 MG/M3

ACGIH TLV: 10 MG/M3

ORGANOPHYLIC CLAY

CAS: 71011-25-1

Fraction By Weight: < 1%

COBALT COMPOUNDS (AS CO)

CAS: 7440-48-4

RTECS: GF8750000

Fraction By Weight: < 1%

OSHA PEL 0.1 MG/M3;AS CO

ACGIH TLV: 2.0 MG/M3;DUST 9293

PROPIETARY INGREDIENTS

Fraction By Weight: BALANCE

3.00 LB/GAL

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: SEVERE IRRITATION,
LACRIMATION, REDNESS, BLURRED VISION. SKIN: REDNESS, IRRITATION.
DEFATTING OF SKIN LEADING TO DERMATITIS. INHALE: NASAL & RESP
IRRITATION, CNS DEPRESSION. DIZZINESS, DR OWSINESS, WEAKNESS,
FATIGUE, CONFUSION.NAUSEA, HEADACHE, VERTIGO, UNCONSCIOUSNESS,
ASPHYXIATION. CHRONIC DERMATITIS.*
Explanation of Carcinogenicity:NA
Effects of Overexposure:*INGESTION: GASTROINTESTINAL IRRITATION,
ABDOMINAL PAIN, NAUSEA, VOMITING, DIARRHEA. TARGET ORGANS: LIVER,
KIDNEYS, EYES, SKIN, RESPIRATORY SYSTEM, CNS, GI TRACT, BLOOD.
CHRONIC EFFECTS OVEREXPOSURE: DERMATITIS, INCOHERENCE, CORNEAL
VACUOLIZATION, ANOREXIA.
Medical Cond Aggravated by Exposure:NONE KNOWN

First Aid:INHAL: GET FRESH AIR. RESTORE BREATHING. GET MED AID IMMED.
SKIN: IMMED FLUSH SKIN W/WATER. IF MATERIAL PENETRATES CLOTHING
REMOVE & WASH BEFORE REUSE. GET MEDICAL ATTENTION. EYES:
IMMEDIATELY FLUSH E YES WITH LOTS WATER > 15 MINS, LIFTING EYELIDS
OCCASIONALLY. GET MED AID IMMED. INGEST: DRINK 1-2 GLASSES WATER.
DON'T INDUCE VOMITING. SEE DR/POINSON CONTROL CTR IMMEDIATELY.
TREAT SYMPTOMATICALLY.

Flash Point Method:TCC
Flash Point:72.0F,22.2C
Lower Limits:0.8
Upper Limits:7.6
Extinguishing Media:DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN
POSITIVE PRESSURE MODE. WATER USED TO COOL CLSD CNTNRS TO PREVENT
BUILDUP & POSSIBLE AUTO IGNITION OR EXPLO EXPOS TO HEAT
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. VAPORS > AIR
TRAVEL ALONG GRND TO AN IGNITION SOURCE. ISOLATE FM ALL HEAT TYPES.
CLSD CNTNRS MAY EXPLODE EXPOSED TO EXTREME HEAT.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. DON'T BREATHE
VAPORS. AVOID SKIN CONTACT. ABSORB WITH INERT MATERIAL. SHOVEL
RECLAIMED INTO DRUMS FOR DISPOSAL. DIKE TO PREVENT FURTHER MOVEMENT
& RECLAIM INTO RECOVERY OR SALVAGE DRUMS OR TANK TRUCK FOR
DISPOSAL.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS.

Respiratory Protection:WEAR AN APPROPRIATE (TYPE TC-23C-75) PROPERLY
FITTED HALF-MASK OF FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING &
AFTER APPLICATION UNLESS AIR MONITORING KEEPS VAPOR/MIST BELOW
APPLICABLE LEVELS. FOLL OW RESPIRATOR MANUFACTURER'S DIRECTIONS.
Ventilation:SUFFICIENT VENT IN VOLUME/PATTERN TO KEEP AIR CONCENTRATION
BELOW ACGIH'S TLV LIMIT.
Protective Gloves:CHEMICAL RESISTANT, NITRILE, VITON
Eye Protection:CHEMICAL/SAFETY GLASSES, FACE SHIELD
Other Protective Equipment:CLOTHING AS NEEDED TO PREVENT SKIN CONTACT
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, USING
RESTROOMS. REMOVE/WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DON'T WEAR CONTACT LENSES WHEN WORKING WITH THIS MATERIAL.

HCC:F3
Boiling Pt:B.P. Text:212 TO 398F
Decomp Temp:Decomp Text:NE
Vapor Density:> AIR
Spec Gravity:1.090
pH:NA
Viscosity:70-75 KU
Evaporation Rate & Reference:< ETHER
Solubility in Water:YES
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:40.99
Corrosion Rate:MINIMAL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, NITRATES, ALKALIES, ACIDS.
Stability Condition to Avoid:HIGH TEMPERATURES, SHOCK FROM DROPPING.
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.